Product ID:LUBRICANT 5000/5001/5005
MSDS Date:07/02/1985
FSC:9150
NIIN:00N050418
MSDS Number: BVDSV

VALVOLINE OIL CO

ASHLAND, KY 41114
US

Emergency Phone: 606-324-1133

Info Phone: 608-329-3333

Preparer: LINDA M. CASEY

Cage: 72527

VALVOLINE OIL CO

14000 LEXINGTON, KY 40512 US

Telephone: 606-357-7206 / 800-274-5263

Cage: 72527

PETROLEUM MINERAL OIL; (ALIPHATIC PETROLEUM DISTILLATES)

CAS: 64742-06-9

Fraction By Weight: 30-60%

OSHA PEL 5 MG/M3 (MFR)

ACGIH TLV: 5 MG/M3 (MFR)

1,2-PROPANEDIOL; (PROPYLENE GLYCOL)

CAS: 57-55-6

RTECS: TY2000000

Fraction By Weight: 1-5%

OSHA PEL N/K

ACGIH TLV: N/K

ETHANOL,2,2',2''-NITRILOTRI-; (TRIETHANOLAMINE)

CAS: 102-71-6

RTECS: KL9275000

Fraction By Weight: 1-5%

OSHA PEL N/K

ACGIH TLV: N/K

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ACUTE:EYES:CAN CAUSE MOD IRRIT,
REDNESS, TEARING. SKIN:CAN CAUSE SLIGHT IRRIT. INHAL:EXCESSIVE
INHAL OF VAPS CAN CAUSE NASAL & RESP IRRIT. INGEST:CAN CAUSE GI
IRRIT, NAUS, VOMIT & DIARR. ASPIR OF MATL INTO LUNGS CAN CAUSE
CHEM PNEUM WHICH CAN BE FATAL. CHRONIC:THIS PROD CNTNS A PARAFFINIC
PETRO OIL (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:SIMILAR IN NATURE TO MINERAL SEAL OIL
WHICH MFR REPORTED TO EPA. REPORT WAS SUBMITTED BASED ON
PRELIMINARY RSLTS OF ONGOING MOUSE SKIN PAINTING STUDY WHICH SHOWED
8 OF AN ORIGINAL 50 ANIMALS DEVEL OBSERVABLE SKIN TUMORS. OVEREXP
TO THIS MATL (OR ITS COMPONENTS) HAS APPARENTLY BEEN FOUND TO CAUSE
(SUPP DATA)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.

First Aid:SKIN:THORO WASH EXPOS AREA W/SOAP & WATER. REMOVE CONTAM
CLTHG. LAUNDER CONTAM CLTHG BEFORE RE-USE. EYES:FLUSH W/LG AMTS OF
WATER FOR AT LST 15 MINS, LIFTING UPPER & LOWER LIDS OCCAS, GET MED
ATTN. IN GEST:DO NOT INDUCE VOMIT, KEEP PERS WARM, QUIET & GET MED
ATTN. ASPIR OF MATL INTL LUNGS DUE TO VOMIT CAN CAUSE CHEM PNEUM
WHICH CAN BE FATAL. INGEST:REMOVE INDIVIDUAL TO FRESH AIR.

Flash Point:>200F,>93C
Extinguishing Media:REGULAR FOAM, CARBON DIOXIDE OR DRY CHEMICAL.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.

Spill Release Procedures:SM SPILL:SWEEP UP MATL FOR DISP/RECOVERY. LG
SPILL:PERSONS NOT WEARING PROT EQUIP SHOULD BE EXCLUDED FROM AREA
OF SPILL UNTIL CLEAN-UP HAS BEEN COMPLETED. SHOVEL MATL INTO
CNTNRS. REMAINING MATL MAY B E TAKEN UP W/SAND, CLAY, EARTH, FLOOR
(SUPP DATA)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:NONE SPECIFIED BY MANUFACTURER.
Other Precautions:CONTAINERS OF THIS MATERIAL MAY BE HAZARDOUS WHEN
EMPTIED. SINCE EMPTIED CONTAINERS RETAIN PRODUCT RESIDUES (VAPOR,
LIQUID &/OR SOLID), ALL HAZARD PRECAUTIONS GIVEN IN THIS MSDS MUST
BE OBSERVED.

Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN . NOT REQUIRED UNDER NORMAL CONDITIONS OF USE.
Ventilation:NOT REQUIRED UNDER NORMAL CONDITIONS OF USE.
Protective Gloves:IMPERVIOUS GLOVES .
Eye Protection:ANSI APPROVED CHEM WORKERS GOGGS .
Other Protective Equipment:NOT REQUIRED UNDER NORMAL CONDITIONS OF USE.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
EFTS OF OVEREXP:FOLLOWING EFTS IN LAB ANIMALS: LIVER ABNORMS, KIDNEY
DMG. SPILL PROC:ABSORB/OTHER ABSORB MATL & SHOVELED INTO CNTNRS.

Boiling Pt:B.P. Text:212F,100C
Vapor Pres:17.5 @ 68F
Vapor Density:HVR/AIR
Spec Gravity:>WATER
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume:>60

Stability Indicator/Materials to Avoid:YES
AVOID CONTACT W/STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:MAY FORM TOXIC MATERIALS: CARBON
DIOXIDE, CARBON MONOXIDE, NITROGEN COMPOUNDS, ETC.

Waste Disposal Methods:SM SPILL:FLUSH DOWN DRAIN W/LARGE AMOUNTS OF
WATER I/A/W APPLICABLE REGULATIONS. LG SPILL:DESTROY BY LIQUID
INCINERATION. CONTAMINATED ABSORBENT MAY BE DEPOSITED IN A LANDFILL
I/A/W LOCAL, STATE & FED ERAL REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.